Carcinogenic:
OSHA = no NTP = no IARC = no
SECTION
III - PHYSICAL DATA
COLOR:
Yellow PHYSICAL FORM: Liquid
ODOR: Slight BOILING
RANGE: N.E.
FREEZING
POINT: N.E. MELTING RANGE: N.A.
pH: N.A. VAPOR
DENSITY: N.E.
EVAPORATION
RATE: N.E. VAPOR PRESSURE: N.E.
DENSITY:
7.7-7.9 lb/gal (0.92-0.94 kg/l)
NON-VOLATILE
CONTENT: 28-35%
SECTION
IV - FIRE AND EXPLOSION DATA
HMIS
FLAMMABILITY RATING: 2
FLASH
POINT: >200ºF (>93ºC)
FLAMMABLE
LIMITS: N.E.
EXTINGUISHING
MEDIA: Carbon dioxide or other dry chemical fire fighting agents.
UNUSUAL
FIRE AND EXPLOSION HAZARDS: None.
SPECIAL
FIRE FIGHTING PROCEDURES: Firefighters should wear self-contained breathing
apparatus.
SECTION
V - HEALTH HAZARD DATA
EMERGENCY
AND FIRST AID PROCEDURES:
Eye
Contact: Flush eyes with water for at least 15 minutes. Consult
a physician. Skin Contact: Wash affected area with soap and water.
If irritation persists, consult a physician. Inhalation: Remove
to an uncontaminated area, administer oxygen if necessary. If victim
has stopped breathing begin CPR. Get medical attention. Ingestion:
If swallowed, do not induce vomiting. Get immediate medical
attention.
MEDICAL
CONDITIONS PRONE TO AGGRAVATION BY
EXPOSURE:
None known. PRIMARY ROUTES OF ENTRY: Inhalation and skin and eye contact.
HEALTH HAZARDS (acute and chronic) / EFFECTS OF OVEREXPOSURE:
1. Eye
contact with this product can cause irritation.
2. Repeated
or prolonged skin contact can cause moderate irritation.
3. Excessive
inhalation of solvent vapors from this product can cause dizziness
and headache.
4. Ingestion
of this material can cause gastrointestinal irritation.
SECTION
VI - REACTIVITY DATA
STABILITY:
Stable
HAZARDOUS
POLYMERIZATION: Will not occur
HAZARDOUS
DECOMPOSITION PRODUCTS: Oxides of carbon, nitrogen and sulfur.
INCOMPATIBILITY:
Strong acids, alkalis and oxidizing agents.
CONDITIONS
TO AVOID: Contact with incompatible materials.
SECTION
VII - SPILL OR LEAK PROCEDURES
STEPS
TO BE TAKEN IN CASE MATERIAL IS RELEASED OR SPILLED: SMALL SPILL: Absorb
on sweeping compound or other absorbent material. WASTE DISPOSAL: SMALL
SPILL: Allow volatile portion to evaporate in hood. Dispose of in accordance
with applicable regulations. LARGE SPILL: Destroy by liquid incineration.
Contaminated absorbent may be deposited in a landfill in accordance
with existing Federal, State and Local environmental regulations.
SECTION
VIII - SAFE HANDLING AND USE INFORMATION
RESPIRATORY
PROTECTION: N.A.
PROTECTIVE
GLOVES: Chemical resistant rubber or plastic.
EYE
PROTECTION: Safety goggles.
OTHER
PROTECTIVE EQUIPMENT: Eye wash station
SECTION
IX - SPECIAL PRECAUTIONS AND STORAGE
PRECAUTIONS
TO BE TAKEN IN HANDLING: Avoid eye and skin contact. Avoid inhalation
of product vapors.
PRECAUTIONS
TO BE TAKEN IN STORING: "Empty" containers retain residue (liquid and/or
vapor) and can be dangerous. DO NOT PRESSURIZE, CUT, WELD, BRAZE, SOLDER,
DRILL, GRIND OR EXPOSE SUCH CONTAINERS TO HEAT, FLAME, SPARKS, OR OTHER
SOURCES OF IGNITION: THEY MAY EXPLODE CAUSING INJURY OR DEATH. Do not
attempt to clean since residue in difficult to remove. Completely drain
"Empty" drums, properly bung and promptly dispose in an environmentally
safe manner and in accordance with governmental regulations. Recycle
drums only through qualified reprocessing organizations.
SECTION
X - SHIPPING DATA
T.S.C.A.
STATUS: N.A.
DOT
SHIPPING NAME: N.A.
U.N.
/ N.A. NUMBER: N.A.
DOT
HAZARD CLASS.: N.A.
DOT
REQUIRED LABELS: N.A.
TECHNICAL
SHIPPING NAME: N.A.
FREIGHT
CLASS BULK: Same as above
LTL:
65 TL: 35 MW: 30
PREPARED
BY: Margarita Kharshan, R&D Manager
APPROVED
BY: Boris Miksic, President/CEO
DATE
PREPARED: 12/4/98 SUPERSEDES: 4/8/97
DISCLAIMER:
This information is furnished without warranty, expressed or implied,
except that it is accurate to the best knowledge of the Cortec Corporation.
The data on this sheet relates only to the specific material designated
herein. The Cortec Corporation assumes no legal responsibility for use
or reliance upon this data.
N.E.
= NOT ESTABLISHED N.A. = NOT APPLICABLE
